Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 1987 Ford Aerostar, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE. Remedy: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.
VANS WERE PRODUCED WITHOUT PLASTIC COVER DESIGNED TO COVER OUTBOARD SEAT BACK PIVOT HINGE ALLOWING WEBBING OF FRONT PASSENGER-SIDE SAFETY BELTS TO BECOME ABRADED OR CUT DUE TO CONTACT WITH EXPOSED HINGE. Remedy: INSTALL PLASTIC PIVOT COVER; REPLACE BELTS AS NECESSARY.
SOME LIFTGATE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS MAY FRACTURE IN EITHER THE OPEN OR CLOSED POSITION. Remedy: REPLACE THE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS.
SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED. Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.
VEHICLES EQUIPPED WITH TRAILER TOW PACKAGE HAVE A TRAILER TAILLIGHT RELAY ASSEMBLY THAT CONTAINS WIRES OF SMALLER GAUGE THAN THE FUSE LINK WHICH PROTECTS THE CIRCUIT. Remedy: INSTALLATION OF A RELAY WITH WIRES OF GAUGE ADEQUATE TO PROTECT THE CIRCUIT.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
THE REAR LIFTGATE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS MAY FRACTURE. IF A BALL STUD FRACTURES, THE LIFTGATE WILL NOT REMAIN IN THE OPEN POSITION. BODILY INJURY COULD RESULT IF THE LIFTGATE DROPS WHILE SOMEONE IS UNDER IT. CORRECTION: BALL STUDS BUILT WITH HIGHER STRENGTH MATERIAL WILL BE INSTALLED ON AFFECTED VEHICLES.
THE WEBBING OF THE FRONT PASSENGER-SIDE SEAT BELTS MAY BECOME ABRADED OR CUT DUE TO CONTACT WITH THE OUTBOARD SEAT BACK PIVOT HINGE. CORRECTION: A PLASTIC COVER WILL BE INSTALLED OVER THE PIVOT HINGE TO PREVENT ABRASION. BELTS WILL BE INSPECTED FOR DAMAGE AND REPLACED IF NECESSARY.
THE AFFECTED VEHICLES ARE EQUIPPED WITH THE OPTIONAL TRAILER TOW PACKAGE. THE TAILLIGHT RELAY ASSEMBLY MAY HAVE WIRES THAT ARE OF A SMALLER GAUGE THAN THE FUSE LINK WHICH IS PROTECTING THE CIRCUIT. A SHORT CIRCUIT IN THE TRAILER WIRING OR WATER INTRUSION INTO THE RELAY ASSEMBLY COULD CAUSE THE SMALLER GAUGE WIRES TO ACT AS A FUSE LINK AND OVERHEAT, CREATING THE POTENTIAL FOR FIRE. CORRECTION: A FUSE WILL BE INSTALLED WITHIN THE TRAILER TOW RELAY POWER FEED CIRCUIT WHICH WILL PROTECT THE RELAY FROM SHORT CIRCUIT OR THERMAL OVERLOAD.
ON VEHICLES WITH EFI OR CFI, THE SPRING-LOCK FUEL LINE COUPLING USED TO CONNECT THE FUEL SUPPLY AND RETURN LINES TO THE EFI FUEL RAILS OR TO THE CFI THROTTLE BODIES AS WELL AS OTHER FUEL LINE CONNECTIONS NEAR THE DASH PANELS ON SOME VEHICLES, COULD DISENGAGE DURING VEHICLE USE. SHOULD THIS OCCUR, LOSS OF FUEL WILL RESULT, PROVIDING THE POTENTIAL FOR A VEHICLE FIRE. CORRECTION: COUPLING RETAINER CLIPS WILL BE INSTALLED ON AFFECTED VEHICLES. NOTE: ESCORT VEHICLES ARE EQUIPPED WITH EFI AND CFI. LYNX VEHICLES ARE EQUIPPED WITH CFI ONLY. EFI - ELECTRONIC FUEL INJECTION CFI - CENTRAL FUEL INJECTION
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain