Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 1990 Mercury Sable, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY. Remedy: MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE. Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
THE RIGID MOUNTED SAFETY BELT BUCKLES ARE DEFECTIVE IN THREE WAYS. FIRST, A FASTENED SAFETY BELT BUCKLE WILL NOT UNLATCH WHEN THE RELEASE BUTTON IS DEPRESSED. THIS RESULTS FROM INTERFERENCE BETWEEN THE BUCKLE EJECTOR FINGER AND THE BUCKLE TONGUE WINDOW. THE SECOND DEFECT IS THE SAFETY BELT BUCKLE MAY NOT LATCH. THE THIRD POSSIBLE DEFECT IS THAT THE TONGUE MAY BE RETAINED BY THE BUCKLE, BUT IT MAY NOT BE LATCHED SUFFICIENTLY TO PROVIDE OCCUPANT PROTECTION. Remedy: FORD WILL REPLACE THE RIGID MOUNTED SAFETY BELT BUCKLES WITH END RELEASE SAFETY BELT BUCKLES DESIGNED TO PREVENT LATCH PROBLEMS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP. Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
THREADED INFLATOR COMPONENTS MAY HAVE BEEN DAMAGED DURING ASSEMBLY WHICH MAY ALLOW COMPONENTS TO SEPARATE WHEN INFLATOR RECEIVES A SIGNAL TO DEPLOY THE AIR BAG. Remedy: REPLACE AIR BAG MODULES CONTAINING POTENTIALLY DEFECTIVE INFLATORS.
FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY. Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.
AN INCORRECT TRANSISTOR MAY CAUSE AUTOLAMP SYSTEM LIGHT SENSOR MODULE MALFUNCTION. Remedy: REPLACE LIGHT SENSOR MODULES.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
On certain vehicles located in Manitoba, Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador, the lower sub frame mount plate nut may corrode and fail due to exposure to road salt. This could result in loss of structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the sub frame which supports the engine and transmission, allows the rear corners of the sub frame to drop. Should both rear corners drop, steering control would be adversely affected. Correction: Dealers will install subframe rear mount bolts, reinforcement plate and plate nuts.
COMPLIANCE TESTING INDICATES THAT THESE VEHICLES MAY BE RELEASING CARBON MONOXIDE (CO) EMISSIONS WHICH EXCEED THE REQUIREMENTS OF C.M.V.S.S. 1103 - EXHAUST EMISSIONS. CORRECTION: CATALYTIC CONVERTER WILL BE REPLACED ON AFFECTED VEHICLES.
NOTE: SUPERSEDED BY 95038. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 1103 - EXHAUST EMISSIONS. CATALYSTS MAY BE RELEASING EMISSIONS IN EXCESS OF THE STANDARD. CORRECTION: EXHAUST SYSTEM CATALYSTS WILL BE REPLACED ON AFFECTED VEHICLES.
On certain vehicles with 3.0 Litre and 3.8 Litre engines, the body mounts on the rear corners of the subframe which supports the engine and transmission may become detached due to corrosion of the rear lower mount retaining plates, allowing the rear corners of the subframe to drop. Should this occur, steering could become very difficult, thereby adversely affecting vehicle control. Correction: modified lower body mounts and attaching bolts will be installed on affected vehicles.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
Crash-test ratings from NHTSA's New Car Assessment Program.
Source: NHTSA (US Department of Transportation) · US public domain
SEAT BELT BUCKLES ON THESE VEHICLES MAY EXPERIENCE CONDITIONS WHEREBY THE BUCKLE MAY NOT UNLATCH WHEN THE RELEASE BUTTON IS DEPRESSED OR MAY NOT LATCH, OR IN SOME CASES, MAY LATCH PARTIALLY BUT NOT SUFFICIENTLY TO PROVIDE OCCUPANT RESTRAINT IN THE EVENT OF A COLLISION. NOTE: ONLY END-RELEASE BUCKLES ON "RIGID" MOUNTINGS ARE SUSCEPTIBLE TO THIS MALFUNCTION. CORRECTION: FACTORY INSTALLED END-RELEASE SEAT BELT BUCKLES WILL BE REPLACED WITH REDESIGNED BUCKLES.
NOTE: VEHICLES EQUIPPED WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S 1105 - EVAPORATIVE EMISSIONS. CORRECTION: PURGE VALVE AND HOSE ASSEMBLY WILL BE REPLACED ON AFFECTED VEHICLES.
NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAYTIME RUNNING LIGHTS THAT DIM, FLICKER OR GO OFF OR IN SOME INSTANCES MAY REMAIN ON AFTER THE IGNITION IS TURNED OFF. CORRECTION: DAYTIME RUNNING LIGHT MODULE WILL BE REPLACED ON AFFECTED VEHICLES.
Note: Station wagon vehicles only. Young children left unattended in the vehicle could lock themselves in the footwell area of the rear-facing third seat (or the underfloor storage compartment in station wagons not equipped with the optional third seat). Once the compartment is closed, it cannot be opened from the inside, and there is the danger of air deprivation, excessive body heat and panic response to a child who may have closed himself or herself in the compartment. Correction: A modified latch will be installed which does not have a self-latching feature and allows the compartment cover to be pushed open from the inside.
THE COMPOSITE CONSTRUCTION FRONT BRAKE ROTORS ON THESE VEHICLES MAY CORRODE, WEAKEN AND FRACTURE, RESULTING IN A REDUCTION OF BRAKING PERFORMANCE. SUCH A FRACTURE WOULD RESULT IN LOSS OF BRAKING AT THE CORRESPONDING FRONT WHEEL WHICH COULD IN TURN RESULT IN INCREASED STOPPING DISTANCE AND A POSSIBLE CRASH. CORRECTION: FRONT BRAKE ROTORS WILL BE REPLACED.
ON VEHICLES EQUIPPED WITH A DRIVER SIDE SUPPLEMENTAL AIR BAG, THE CENTRE POST THREADS OF THE AIR BAG MODULE MAY HAVE BEEN DAMAGED DURING ASSEMBLY. IN A DEPLOYMENT LEVEL COLLISION, THE CENTRE POST HOUSING MAY SEPARATE FROM THE AIR BAG ADAPTER CAUSING THE AIR BAG NOT TO INFLATE PROPERLY. IN ADDITION, HOT COMBUSTION GASES WOULD FLOW DIRECTLY THROUGH THE AIR BAG RATHER THAN THROUGH THE NORMAL FILTERING AND COOLING DEVICES, PRESENTING THE POSSIBILITY OF BURN INJURY TO VEHICLE OCCUPANTS. CORRECTION: AIR BAG MODULES WILL BE INSPECTED AND REPLACED IF NECESSARY.
AN INCORRECT TRANSISTOR IN THE AUTOLAMP HEADLAMP CONTROL SYSTEM MODULE MAY MALFUNCTION AND CAUSE THE HEADLAMPS TO TURN OFF WHILE THE VEHICLE IS BEING DRIVEN. THIS COULD CAUSE IMPAIRED DRIVER VISION AND A POSSIBLE VEHICLE CRASH. CORRECTION: AUTOLAMP LIGHT SENSOR MODULE WILL BE REPLACED ON AFFECTED VEHICLES.