Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 1991 Ford Aerostar, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE. Remedy: AIMCO WILL REIMBURSE CONSUMERS/INSTALLERS FOR THE COST OF REPLACEMENT ROTORS AND INSTALLATION. CONSUMERS ARE REQUESTED TO RETURN TO THE LOCATION WHERE THE ROTORS WERE ORIGINALLY PURCHASED/INSTALLED FOR REPLACEMENT.
SEAT BELT ANCHORAGE BAR FOR REAR SOFA FAILED TO SUSTAIN LOADS REQUIRED BY FMVSS 210. Remedy: REPLACE NONCOMPLYING SOFA BAR WITH BAR THAT MEETS REQUIREMENTS.
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT. Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR. Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
Certain vehicles, from Ontario to Newfoundland, could experience a corrosion related failure of the spare tire winch cable. If the cable breaks while the vehicle is being driven, the spare tire could drop down, potentially creating a roadway obstacle. Correction: Owners are to inspect the cable, and if corrosion or broken wire strands are present the vehicle is to be taken to a dealer for replacement of the winch assembly. Program ends September 30, 2003.
A SHORT CIRCUIT COULD DEVELOP IN THE IGNITION SWITCH THAT COULD LEAD TO OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN OF THE VEHICLE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS IN USE OR UNATTENDED. CORRECTION: IGNITION SWITCH WILL BE REPLACED WITH A REVISED DESIGN SWITCH.
NOTE: ALSO INCLUDES SOME MEDIUM AND HEAVY TRUCKS. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 108 - LIGHTING. DAYTIME RUNNING LIGHT MODULE MAY MALFUNCTION WHICH CAN RESULT IN DAYTIME RUNNING LIGHTS THAT DIM, FLICKER OR GO OFF OR IN SOME INSTANCES MAY REMAIN ON AFTER THE IGNITION IS TURNED OFF. CORRECTION: DAYTIME RUNNING LIGHT MODULE WILL BE REPLACED ON AFFECTED VEHICLES.
NOTE: TEMPO/TOPAZ WITH 2.3 LITRE ENGINE AND AEROSTAR WITH 3.0 LITRE ENGINE. THESE VEHICLES SO NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. DEFECTIVE THROTTLE POSITION SENSORS CAN WEAR OUT PREMATURELY CAUSING AN INTERRUPTION OF THE SENSOR SIGNAL AND ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT. CORRECTION: THROTTLE POSITION SENSOR WILL BE INSPECTED AND REPLACED IF NECESSARY.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
THE PARK MECHANISM OF THE A4LD AUTOMATIC TRANSMISSION MAY NOT ENGAGE WHEN THE SELECTOR LEVER IS PLACED IN THE "PARK" POSITION. IF PARKED ON AN INCLINE, THE VEHICLE MAY ROLL AS IF IN NEUTRAL IF THE PARKING BRAKE IS NOT SET. THIS COULD RESULT IN A VEHICLE ACCIDENT OR PERSONAL INJURY. CORRECTION: OWNERS WILL BE NOTIFIED OF CONDITION AND ADVISED TO SET THE PARKING BRAKE EACH TIME THEY PARK THEIR VEHICLE. OWNERS WILL ALSO BE ADVISED WHEN DEALERS RECEIVE PARTS AND REPAIR INSTRUCTIONS AFTER FURTHER INVESTIGATION BY FORD.