Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 1992 Mercury Sable, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
THE ARC WELDS ON THE SWAY BAR BRACKET, WHERE IT ATTACHES TO THE STRUT RESERVE TUBE, DID NOT FUSE PROPERLY. Remedy: MONROE DEALERS WILL REPLACE THE STRUT FREE OF CHARGE.
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING. Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE. Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT. Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP. Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
On certain vehicles located in Manitoba, Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador, the lower sub frame mount plate nut may corrode and fail due to exposure to road salt. This could result in loss of structural integrity of the subframe mount attachment. Detachment of the body mounts at the rear corners of the sub frame which supports the engine and transmission, allows the rear corners of the sub frame to drop. Should both rear corners drop, steering control would be adversely affected. Correction: Dealers will install subframe rear mount bolts, reinforcement plate and plate nuts.
VEHICLES WITH 3.8 LITRE ENGINES THAT WERE INVOLVED IN SAFETY RECALL 95S22 (95-202) WERE MODIFIED WITH A MAXI-FUSE THAT DOES NOT PROVIDE THE INTENDED LEVEL OF PROTECTION FOR THE ENGINE COOLING FAN ELECTRICAL SYSTEM. ALSO, BECAUSE A SIMILAR MAXI-FUSE CIRCUIT WAS USED ON CERTAIN 1994-95 TAURUS/SABLE VEHICLES WITH 3.8 LITRE ENGINES, THESE VEHICLES WILL BE INCLUDED IN THIS RECALL. CORRECTION: A FUSED WIRING HARNESS THAT PROVIDES THE REQUIRED LEVEL OF PROTECTION WILL BE INSTALLED ON AFFECTED VEHICLES.
DIRECT WATER SPRAY OR LONG TERM WET DRIVING CONDITIONS MAY CAUSE WATER TO ACCUMULATE IN THE SPEED CONTROL CABLE CONDUIT. UNDER COLD CONDITIONS THIS WATER COULD FREEZE AND PREVENT THE THROTTLE FROM RETURNING TO THE CLOSED POSITION WHEN THE SPEED CONTROL IS DISENGAGED. THIS COULD ADVERSELY AFFECT DRIVER CONTROL AND CREATE THE POTENTIAL FOR A VEHICLE CRASH. CORRECTION: MOISTURE WILL BE REMOVED FROM THE CABLE CONDUIT AND A BOOT WILL BE ADDED TO THE SPEED CONTROL CABLE TO PREVENT WATER ENTRY.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
Crash-test ratings from NHTSA's New Car Assessment Program.
Source: NHTSA (US Department of Transportation) · US public domain
NOTE: 1992-94 TEMPO/TOPAZ WITH 3.0 LITRE ENGINES; 1994-95 TAURUS/SABLE (EXCEPT SHO) WITH 3.0 LITRE ENGINES; 1992-93 TAURUS/SABLE WITH 3.8 LITRE ENGINES; 1992-94 LINCOLN CONTINENTAL. THE ENGINE COOLING FAN MAY BECOME FROZEN IN PLACE BY SNOW, ICE OR SLUSH. IF THIS OCCURS AND THE COOLING FAN IS ACTIVATED, EITHER AUTOMATICALLY TO REDUCE COOLANT TEMPERATURE OR WHEN THE DEFROSTER IS TURNED ON, THE COOLING FAN WILL NOT ROTATE AND CAN OVERHEAT. THIS CAN DAMAGE THE FAN MOTOR, FAN, FAN WIRING AND SHROUD WITH THE POTENTIAL FOR SMOKE OR A FIRE TO RESULT. CORRECTION: IN SOME CASES, THE FUSE FOR THE COOLING FAN CIRCUIT WILL BE REPLACED WITH A SMALLER FUSE. IN OTHER CASES, A JUMPER HARNESS WITH DEDICATED CIRCUIT PROTECTION FOR THE COOLING FAN WILL BE INSTALLED.
On certain vehicles with 3.0 Litre and 3.8 Litre engines, the body mounts on the rear corners of the subframe which supports the engine and transmission may become detached due to corrosion of the rear lower mount retaining plates, allowing the rear corners of the subframe to drop. Should this occur, steering could become very difficult, thereby adversely affecting vehicle control. Correction: modified lower body mounts and attaching bolts will be installed on affected vehicles.
NOTE: VEHICLES WITH 3.8 LITRE ENGINES. THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 1103 - EXHAUST EMISSIONS. VEHICLES WERE MANUFACTURED WITH INCORRECT ELECTRONIC ENGINE CONTROL (EEC) PROCESSORS. CORRECTION: EEC PROCESSOR WILL BE REPLACED ON AFFECTED VEHICLES.
Note: Station wagon vehicles only. Young children left unattended in the vehicle could lock themselves in the footwell area of the rear-facing third seat (or the underfloor storage compartment in station wagons not equipped with the optional third seat). Once the compartment is closed, it cannot be opened from the inside, and there is the danger of air deprivation, excessive body heat and panic response to a child who may have closed himself or herself in the compartment. Correction: A modified latch will be installed which does not have a self-latching feature and allows the compartment cover to be pushed open from the inside.