Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 1996 Ford Taurus, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS. Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT. Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
THE PARK PAWL SHAFT WAS IMPROPERLY POSITIONED WHEN THE ROLL PIN THAT RETAINS IT WAS INSTALLED DURING TRANSMISSION ASSEMBLY. IF THE SHAFT WAS NOT PROPERLY POSITIONED, THE ROLL PIN MAY NOT HAVE LINED UP WITH THE GROOVE IN THE SHAFT AND HAVE BEEN CRUSHED AT ASSEMBLY. ALSO, A BURR COULD HAVE BEEN RAISED ON THE SHAFT. Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROLL PIN. IF THE ROLL PIN IS DAMAGED, BOTH THE ROLL PIN AND THE PARK PAWL SHAFT WILL BE REPLACED. IN ADDITION, OWNERS WILL BE REMINDED TO FULLY APPLY THE PARKING BRAKE, IN ADDITION TO PLACING THE TRANSMISSION IN PARK.
THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCH CAN MALFUNCTION. THIS DOES NOT COMPLY WITH FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." Remedy: DEALERS WILL REPLACE THE BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES PREVIOUSLY SERVICED UNDER FORD SERVICE BULLETIN 97-17-9 FROM AUGUST 1997 THROUGH DECEMBER 1997. THESE VEHICLES WERE INADVERTENLY EQUIPPED WITH AN 18-GALLON FUEL TANK RATHER THAN THE 16-GALLON AS SPECIFIED. THE 18-GALLON TANK HAS A SECOND VALVE LOCATION WHERE A SHIPPING PLUG SHOULD BE INSTALLED. Remedy: DEALERS WILL INSTALL THE CORRECT FUEL TANK.
THE AUTOMATIC TRANSMISSION PARK PAWL SHAFT MAY NOT BE FREE TO ROTATE AS INTENDED. IF THE PARK PAWL SHAFT DOES NOT ROTATE, IT WOULD PREVENT THE PARK PAWL FROM ENGAGING THE PARK GEAR WHEN THE SHIFT LEVER IS IN THE PARK POSITION. Remedy: DEALERS WILL INSPECT THE PARK PAWL SHAFT ROTATION AND THOSE SHAFTS WITH RESTRICTED ROTATION WILL BE REPLACED WITH A SHORTER SHAFT THAT WILL NOT RESTRICT ROTATION.
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH CAN CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS WOULD ALLOW THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK. Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET.
THE FUEL PRESSURE REGULATOR LOCATED ON THE FUEL RAIL IN THE ENGINE COMPARTMENT HAS A VACUUM DIAPHRAGM THAT WAS DAMAGED DURING MANUFACTURE OF THE REGULATOR. Remedy: DEALERS WILL INSPECT THE FUEL PRESSURE REGULATOR. THOSE REGULATORS PRODUCED DURING THE SUSPECT TIME PERIOD WILL BE REPLACED.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
VEHICLES THAT WERE SERVICED FOR A STALL CONDITION BETWEEN AUGUST 1, 1997 AND DECEMBER 1, 1997 MAY HAVE RECEIVED AND INCORRECT FUEL TANK. THE INCORRECT TANK CONTAINS AN ADDITIONAL VENT HOLE WHICH PROVIDES THE POTENTIAL FOR A FUEL LEAK. CORRECTION: VEHICLES WILL BE INSPECTED AND FUEL TANK WILL BE REPLACED WITH THE CORRECT TANK IF NECESSARY.
NOTE: FLEXIBLE FUEL VEHICLES. A SEAL FOR THE FUEL DELIVERY MODULE WIRING HARNESS CONNECTOR MAY SWELL IN THE PRESENCE OF UNLEADED FUEL AND FORCE THE CONNECTOR APART CREATING AN OPEN CIRCUIT. THIS WOULD RESULT IN LOSS OF FUEL PUMP OPERATION AND FUEL PRESSURE. IN ADDITION, THE VAPOUR CONTROL VALVES, LOCATED ON THE FUEL TANK MAY NOT OPERATE PROPERLY RESULTING IN VAPOUR EMISSIONS IN EXCESS OF THE STANDARD. CORRECTION: WIRING CONNECTOR SEAL AND FUEL TANK VAPOUR VENT VALVE ASSEMBLY WILL BE REPLACED.
THE AUTOMATIC TRANSAXLE PARK MECHANISM MAY NOT PREVENT THE VEHICLE FROM ROLLING EVEN IF THE TRANSAXLE SHIFT LEVER IS FIRMLY PLACED IN THE "PARK" POSITION. IF THE DRIVER IS UNAWARE THAT THE PARK MECHANISM OF THE TRANSAXLE HAS NOT PROPERLY ENGAGED AND LEAVES THE VEHICLE UNATTENDED WITHOUT SETTING THE PARKING BRAKE, THE VEHICLE COULD BE FREE TO ROLL AS IF IN NEUTRAL. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING. CORRECTION: PARK MECHANISM WILL BE INSPECTED AND, IF NECESSARY, A NEW PARK PAWL SHAFT WILL BE INSTALLED IN THE TRANSAXLE.
THE PARK PAWL ABUTMENT BRACKET HAS A SHARP EDGE WHICH MAY CAUSE THE PARKING PAWL TO HANG UP AND NOT ENGAGE THE PARK GEAR. THIS MAY CAUSE THE VEHICLE TO MOVE EVEN THOUGH THE GEAR SHIFT INDICATOR SHOWS THAT THE VEHICLE IS IN PARK. AS A RESULT, UNINTENDED AND UNEXPECTED VEHICLE MOVEMENT COULD OCCUR WITH THE POSSIBILITY OF PERSONAL INJURY AND PROPERTY DAMAGE. CORRECTION: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE PARK PAWL ABUTMENT BRACKET ON AFFECTED VEHICLES.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
Crash-test ratings from NHTSA's New Car Assessment Program.
Source: NHTSA (US Department of Transportation) · US public domain
On certain Taurus SHO, the fuel pressure regulator diaphragm may rupture. Should this occur, engine damage or fuel leakage could result. Fuel leakage in the presence of an ignition source could potentially result in a fire. Correction: Vehicles will be inspected and fuel pressure regulators will be replaced where required.
NOTE: VEHICLES EQUIPPED WITH FORD AX4S AUTOMATIC TRANSAXLES. THE PARK PAWL SHAFT MAY HAVE BEEN IMPROPERLY POSITIONED DURING TRANSMISSION ASSEMBLY. THIS COULD RESULT IN THE PARK PAWL NOT ENGAGING WHEN THE TRANSMISSION SELECTOR IS PLACED IN THE PARK POSITION. THIS COULD ALLOW THE VEHICLE TO ROLL AS IF IN NEUTRAL IF THE VEHICLE OPERATOR DOES NOT APPLY THE PARKING BRAKE. CORRECTION: VEHICLES WILL BE INSPECTED AND IF NECESSARY THE PARK PAWL SHAFT ROLL PIN AND PARK PAWL SHAFT WILL BE REPLACED.
THESE VEHICLES MAY NOT COMPLY WITH C.M.V.S.S. 105 - HYDRAULIC BRAKE SYSTEMS. THE BRAKE SYSTEM FLUID LEVEL INDICATOR MAY MALFUNCTION WHICH COULD CAUSE THE BRAKE SYSTEM WARNING LAMP TO: (1) REMAIN ILLUMINATED CONTINUOUSLY, OR (2) FAIL TO ILLUMINATE AS INTENDED SHOULD THE FLUID LEVEL FALL TO A CERTAIN LEVEL. CORRECTION: BRAKE SYSTEM FLUID LEVEL INDICATOR LAMP SWITCHES WILL BE REPLACED ON AFFECTED VEHICLES.