Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 1998 Western Star 4900, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY. Remedy: DEALERS WILL REPLACE BOTH FRONT HUBS. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR 3406E AND C-15 ENGINES, INTERFERENCE BETWEEN THE POSITIVE BATTERY CABLE AND STUD MOUNTING ELECTRONIC CONTROL MODULE (ECM) TO THE ENGINE EXISTS. CHAFING CAN WEAR THROUGH THE BATTERY CABLE INSULATION TO ALLOW CONTACT BETWEEN THE BATTERY CABLE AND THE STUD. Remedy: DEALERS WILL INSPECT THE VEHICLES AND THE BATTERY CABLES WILL BE REPLACED AND/OR RE-ROUTED AS NECESSARY. OWNER NOTIFICATION BEGAN APRIL 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
On certain vehicles fitted with optional in-cab batteries, fuel lines may contact the cab power harness, resulting in chafe damage that could present a fire hazard. Correction: Dealers will reroute and secure the fuel lines.
On certain vehicles, manufacturing defects in the front axle unitized hubs may cause premature spalling of the wheel bearings. This condition will lead to eventual breakdown of the bearing and potential loss of vehicle control amidst the presence of warning signals such as activation of ABS warning light, steering wheel vibration, brake drag, noise and vehicle pull. Correction: Dealer will replace both front wheel hubs.
The TRW tie rod and drag link ball stud ends contain bearings that are below the specified case depth and/or hardness. This can lead to premature wear out and a possible separation of the ball stud from the socket and loss of steering control. Correction: All affected tie rods and drag links with different design ends will be replaced.
On certain trucks the positive battery cable routing past the ECM may allow the cable to chafe against the ECM mounting stud. Chafing may wear through the protective loom and battery cable insulation to allow contact between the cable and the stud. This contact would provide a short circuit which may cause a fire. Correction: Dealers will replace and/or reroute the cables.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain