Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2004 IC CE, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
NAVISTAR IS RECALLING 61,316 MY 2001 THROUGH 2009 IC BE, CE, AND FE MODEL COMMERCIAL AND SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 2, 2000 AND JUNE 2, 2008, EQUIPPED WITH AN ENTRANCE DOOR STEPWELL HEATER FEATURE CODE 0048PMS OR 0548001 AND/OR A REAR WALL MOUNTED HEATER FEATURE CODE 0048TAR OR 0048PSX. THE AFFECTED HEATER UNITS MAY FAIL IN LOW SPEED OPERATION CAUSING ELEVATED TEMPERATURES. Remedy: AN INTERIM LETTER WAS MAILED ON FEBRUARY 20, 2009, TO COMMUNICATE THE DEFECT AND RECOMMEND ACTION TO MITIGATE THE RISK UNTIL THE FINAL REMEDY AND CUSTOMER NOTIFICATION COULD BE PROVIDED AT A LATER DATE. THE MANUFACTURE FILED AN AMENDED DEFECT REPORT DATED MARCH 27, 2009 ADVISING THAT A FINAL REMEDY HAS BEEN DEVELOPED AND PARTS ARE BEING MANUFACTURED. THE SAFETY RECALL BEGAN ON JUNE 2, 2009. OWNERS MAY CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.
CERTAIN 1998, 2000-2005 MY CE, FE, AND RE SCHOOL BUSES BUILT WITH ONE OR MORE CE WHITE 30-INCH CHILD RESTRAINT SEATS AND MANUFACTURED BETWEEN MARCH 25, 1998 AND AUGUST 24, 2004. THE SEAT CUSHION RETENTION MAY NOT RETAIN THE SEAT IN ALL CIRCUMSTANCES. Remedy: IC CORP WILL NOTIFY ITS CUSTOMERS AND WILL REPAIR THE CUSHION BY ADDING A CLIP TO THE CUSHION TYING IT TO THE SEAT FRAME. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.
CERTAIN MY 2001-2005 AMTRAN/IC CORPORATION CE, FE, AND RE SCHOOL BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH. Remedy: SURE-LOK WILL NOTIFY IC'S CUSTOMERS AND REPAIR THE BUSES ON IC'S BEHALF AT NO COST TO THE CUSTOMER. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK AT 1-908-231-1804.
ON CERTAIN "SPECIAL NEEDS" SCHOOL BUSES EQUIPPED WITH SUR-LOC "L" WHEELCHAIR TRACKS, THE LIFT MOUNTING BOLTS COULD CORRODE IF MOISTURE OCCURS IN THE TREATED PLYWOOD FLOOR. Remedy: DEALERS WILL REPLACE THE SUR-LOC "L" TRACKS WITH PROTECTED TRACKS AND MOUNTING HARDWARE. ALSO, LIFT FLOOR-MOUNTING BOLTS WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN MARCH 19, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC AT 1-800-843-5615.
NAVISTAR IS RECALLING 24,975 MY 2003 THROUGH 2008 IC BE, CE, HC, AND RE SCHOOL AND COMMERCIAL BUSES AND 2002 THROUGH 2008 INTERNATIONAL 3200 AND 3300 MODEL BUSES MANUFACTURED BETWEEN SEPTEMBER 21, 2001 THROUGH DECEMBER 14, 2007, EQUIPPED WITH INTERNATIONAL VT365 ENGINES. THESE VEHICLES MAY EXHIBIT ENGINE HARD START, NO START, OR STALL CONDITIONS DUE TO POSSIBLY DAMAGED TERMINALS IN THE FUSE HOLDER CONNECTOR OF THE INJECTOR DRIVE MODULE (IDM) CLEAN BATTERY POWER CIRCUITS. THE TERMINALS MAY HAVE BEEN DAMAGED DURING ELECTRICAL CONTINUITY TESTING IN THE MANUFACTURING PROCESS. Remedy: NAVISTAR WILL NOTIFY OWNERS AND REPLACE THE IDM FUSE HOLDER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 3, 2008. OWNERS CAN CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.
NAVISTAR IS RECALLING 51,588 HEAVY TRUCKS, COMMERCIAL BUSES AND SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 21, 2000 AND MAY 21, 2008, EQUIPPED WITH ONE OR MORE REMOTE POWER MODULES. THE POTTING MATERIAL THAT ENCAPSULATES THE CIRCUIT BOARD OF THE VEHICLE'S REMOTE POWER MODULE MAY NOT SUFFICIENTLY SEAL THE CIRCUIT BOARD FROM WATER AND CONTAMINATION INTRUSION. IF THE ENCAPSULATION IS COMPROMISED, WATER AND CONTAMINANTS MAY CAUSE AN INTERNAL ELECTRICAL SHORT, POSSIBLY RESULTING IN A FIRE. Remedy: NAVISTAR WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2008. OWNERS MAY CONTACT NAVISTAR AT 1-280-461-1890.
CERTAIN 2004-2006 MY IC CORPORATION CE, FE, AND RE SCHOOL BUSES MANUFACTURED FROM MAY 12, 2003, THROUGH MARCH 2, 2005, EQUIPPED WITH CHILD RESTRAINT ANCHORAGE SYSTEMS. THE DIAMETER LATCH ATTACHMENT BARS EXCEED THE DIAMETER REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, CHILD RESTRAINT ANCHORAGE SYSTEMS, WHICH MAY MAKE IT DIFFICULT TO USE WITH FUTURE CAR SEAT ATTACHMENTS. IN ADDITION, SOME OF THE LATCH ATTACHMENTS ARE LOCATED TOO FAR FORWARD OF THE SEAT BACK. Remedy: IC CORPORATION WILL NOTIFY ITS CUSTOMERS AND (1) THE BRACKETS WILL BE REMOVED AND REPLACED BY A SPECIAL BELT SYSTEM AND (2) THE SEAT FRAME WILL BE REPLACED BY A FRAME WITH A NEW SEAT ATTACHMENT BRACKET. THESE REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 19, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 260-461-1924.
CERTAIN 2003-2006 MY IC CE, FE, AND RE SCHOOL BUSES AND RE COMMERCIAL BUSES MANUFACTURED BETWEEN FEBRUARY 4, 2003, AND MARCH 1, 2005, AND EQUIPPED WITH WEBASTO COOLANT HEATERS. THE STAINLESS STEEL WALLS OF THE BURNER TUBES INCORPORATED INTO WEBASTO COOLANT HEATERS MAY BE MADE OF A MATERIAL THAT IS NOT WITHIN SPECIFICATION AND MAY FAIL PREMATURELY. Remedy: IC WILL NOTIFY ITS OWNERS AND REPLACE THE BURNER TUBES FREE OF CHARGE. THE RECALL BEGAN ON APRIL 20, 2005. OWNERS MAY CONTACT INTERNATIONAL AT 260-461-1924.
CERTAIN MY 2004 THROUGH 2007 CE AND BE SCHOOL BUSES AND 1300 AND 3300 MODEL VEHICLE CHASSIS MANUFACTURED BY IC CORPORATION BETWEEN MARCH 17, 2004, AND MAY 15, 2006. THE PARK BRAKE SYSTEM MAY ACTIVATE WHILE THE VEHICLE IS UNDER NORMAL OPERATION. ALTHOUGH THE VEHICLE IS BROUGHT TO A STOP, THE ACTIVATION MAY OCCUR WITHOUT WARNING OR INPUT FROM THE DRIVER AND MAY STRAND THE VEHICLE IN AN ACTIVE LANE. THE SPRING APPLIED, HYDRAULIC RELEASE (SAHR) PARK BRAKE ACTUATOR COULD EXPERIENCE A HYDRAULIC LOCK CONDITION THAT WILL NOT ALLOW THE PARK BRAKE TO APPLY. Remedy: DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN JULY 7, 2006. OWNERS MAY CONTACT IC CORPORATION AT 800-322-2884 OR OWNERS MAY CONTACT INTERNATIONAL AT 1-800-448-7825.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain