Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2004 Pontiac Aztek, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
ON CERTAIN SPORT UTILITY VEHICLES, CONTAMINATION ON IGNITION RELAY CONTACTS CAN CAUSE HIGH RESISTANCE. THIS CAN AFFECT SIGNALS TO THE POWERTRAIN CONTROL MODULE AND, COULD CAUSE INTERMITTENT VEHICLE STALLS AT ANY TIME. Remedy: DEALERS WILL REPLACE THE IGNITION RELAY FREE OF CHARGE. THE RECALL BEGAN ON MAY 4, 2005. OWNERS MAY CONTACT PONTIAC AT 1-800-620-7668 AND BUICK AT 1-866-608-8080.
ON CERTAIN VEHICLES, VARIATIONS IN THE MANUFACTURING PROCESS OR EXPOSURE TO HIGH AMBIENT TEMPERATURES MAY LEAD TO FRACTURE OF THE FUEL TANK INLET CHECK VALVE (ICV). Remedy: DEALERS WILL REPLACE THE FUEL TANK. THE RECALL WILL BE MAILED IN TWO PHASES WITH THE FIRST PHASE BEGINNING ON DECEMBER 4, 2007. THE SECOND PHASE WILL BE MAILED ON DECEMBER 13, 2007. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OR PONTIAC AT 1-800-620-7668. THE VEHICLE POPULATION INCLUDES BUICK RENDEZVOUS AND PONTIAC AZTEK VEHICLE BUILT IN MAY 2003; CHEVROLET VENTURE AND PONTIAC MONTANA VEHICLES BUILT FROM JUNE THROUGH AUGUST 2002; AND ALL VEHICLES REGISTERED IN NEVADA, ARIZONA, VIRGIN ISLANDS, PUERTO RICO, AND HAWAII.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER. Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
ON CERTAIN PASSENGER VEHICLES, A WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK CAN FAIL. Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER OF THE FUEL TANK TO SEE IF IT IS ON THE LIST OF AFFECTED TANKS. IF THE SERIAL NUMBER MATCHES, THE FUEL TANK WILL BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 4, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080 OR PONTIAC AT 1-800-620-7668.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
On certain Aztek (AWD), Montana (AWD), Relay (AWD), RendezVous (AWD), RendezVous (FWD), Silhouette (AWD), Terraza (AWD), Terraza (FWD), Uplander (AWD) and Venture (AWD) vehicles equipped with independent rear suspension, when operated in extreme cold temperature and on rough roads, water and salt can intrude past the ball joint seal. The combination of theses conditions may then lead to premature wear of the ball joint. If the ball joint wear progresses to the point of separation from the lower control arm, a loss of vehicle control may occur. Correction: Dealers will replace both ball joints with new ball joints which have a revised boot and ball stud to improve the seal to the ball stud shaft.
On certain vehicles, contamination on ignition relay contacts can cause high resistance. This can affect signals to the powertrain control module, which could result in intermittent engine stalling. In some cases, the vehicle cannot be restarted immediately. If this were to occur, it could result in a vehicle crash. Correction: Dealers will replace the ignition relay.
On certain vehicles, a weld between the fuel tank inlet valve and the fuel tank was not made to specification and can fail. If these parts separate, the driver may notice an odour of fuel, the Service Engine Soon or Check Engine light may illuminate, and/or fuel may leak onto the ground. If a sufficient amount of fuel leaked and if an ignition source were present, a vehicle fire could occur. Correction: Dealer will inspect the fuel tank and replace it if necessary.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
Crash-test ratings from NHTSA's New Car Assessment Program.
Source: NHTSA (US Department of Transportation) · US public domain