Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2005 Bigdog Mastiff, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
ON CERTAIN MOTORCYCLES, THE REAR WHEEL HUB BOLTS COULD LOOSEN AND BACK OUT ALLOWING THE HUB AND BRAKE ROTOR TO DETACH FROM THE WHEEL WITH AN ASSOCIATED LOSS OF STOPPING POWER. Remedy: DEALERS WILL REMOVE, CLEAN AND REATTACH THE REAR HUB BOLTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 14, 2005. OWNERS MAY CONTACT BIG DOG AT 1-312-267-9121.
ON CERTAIN MOTORCYCLES, THE ELECTRONIC HARNESS CONTROL (EHC) MODULE CAN FAIL RESULTING IN A TOTAL SHUT DOWN OF THE VEHICLE'S ELECTRONIC POWER. Remedy: DEALERS WILL REPLACE THE EHC MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 19, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
ON CERTAIN MOTORCYCLES, THE IGNITION MODULES ARE ORIENTED WITHIN THE BATTERY TRAY IN A WAY THAT MAKES THE IGNITION MODULE SUSCEPTIBLE TO VIBRATION. Remedy: DEALERS WILL INSTALL A NEW IGNITION MODULE MOUNTING SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 25, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
ON CERTAIN MOTORCYCLES, THE LONG PIVOT BOLT MAY BEND OR BREAK DURING NORMAL OPERATION OF THE MOTORCYCLE. Remedy: DEALERS WILL REPLACE THE LONG PIVOT BOLT AND, IF NECESSARY, STRAIGHTEN THE REAR FRAME SIDE PANEL. THE SHORT LEFT SIDE PIVOT BOLT AND PIVOT SHAFT MAY ALSO BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 1, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
ON CERTAIN MOTORCYCLES, THE PRIMARY DRIVE SPROCKET NUT MAY BACK OFF THE ENGINE MAIN SHAFT. Remedy: DEALERS WILL INSPECT AND REPLACE THE DRIVE SPROCKET NUT FREE OF CHARGE. THE RECALL BEGAN ON MAY 13, 2005. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
ON CERTAIN MOTORCYCLES, A WARPED BUS BAR WITHIN THE VOLTAGE REGULATOR CAN CAUSE A SHORT CIRCUIT. Remedy: DEALERS WILL REPLACE THE EXISTING CIRCUIT BREAKER LOCATED BETWEEN THE VOLTAGE REGULATOR POSITIVE BATTERY LEAD (B+ LEAD) AND THE POSITIVE BATTERY TERMINAL WITH AN ALTERNATIVE CIRCUIT PROTECTION DEVICE THAT WILL PREVENT A THERMAL EVENT IF THERE IS A SHORT TO GROUND. THE RECALL BEGAN ON OCTOBER 1, 2007. OWNERS MAY CONTACT BIG DOG AT 1-316-219-9129 OR EMAIL TO CUSTOMER.SERVICE@BIGDOGMOTORCYCLES.COM.
ON CERTAIN MOTORCYCLES, THE KICKSTAND SPRING MAY STRETCH AND DETACH FROM THE MOUNTING BRACKET OR THE KICKSTAND. Remedy: DEALERS WILL INSTALL A NEW KICKSTAND SPRING FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
ON CERTAIN MOTORCYCLES, THE REAR FENDER STRUT ATTACHING BOLTS CAN FAIL ALLOWING THE REAR FENDER TO DETACH FROM THE MOTORCYCLE. Remedy: DEALERS WILL REMOVE EXISTING STRUT BOLTS AND REPLACE WITH HIGHER TENSILE STRENGTH ATTACHING BOLTS AND UPDATED WASHERS. HIGHER TORQUE VALUES WILL BE OBSERVED WHEN INSTALLING THE REPLACEMENT FASTENERS. THE RECALL BEGAN ON JANUARY 21, 2008. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain