Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2005 Itasca Sunrise, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT. Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO IS RECALLING 2,331 MY 2002-2004 BRAVE AND ITASCA SUNRISE MY 2005 2006 WINNEBAGO VOYAGE, ADVENTURER, ITASCA SUNRISE AND SUNCRUISER MOTOR HOMES. THE PROPANE TANK MOUNTING BRACKET MAY HAVE AN INCOMPLETE OR IMPROPER WELD. Remedy: DEALERS WILL INSPECT AND PROPERLY WELD THE BRACKET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT WINNEBAGO AT 800-537-1885.
ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED. Remedy: DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.
ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER. Remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.
CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
Certain refrigerators used in Recreational Vehicles (RVs) contain either a sensing algorithm or a thermal switch to interrupt power when it detects high temperatures that could lead to a fire. An insufficient response time can result in the power not being shut-off in sufficient time to prevent a fire, which could result in property damage and/or personal injury. Correction: Dealers will install a thermocouple with a faster response time for all refrigerators with a sensing algorithm or a thermal switch.
On certain motorhomes, the brake calipers may stick in the applied position. This can result in abnormal heat generation at the wheel end which, if undetected, could eventually lead to soft brake pedal condition due to brake fluid boil. Extended stopping distances may result in a vehicle crash causing property damage, personal injury or death. Correction: Dealers will affect repairs.
On certain motorhomes, the propane tank mounting bracket may have been incorrectly welded during vehicle assembly. Should the weld fail, the propane tank can tip or fall. An errant propane tank could strike a vehicle, property, or a bystander. A propane gas leak, in the presence of an ignition source, could result in a fire or an explosion, which could cause property damage, personal injury or death. Correction: Dealers will inspect and, if required, repair weld the bracket.
On certain motorhomes equipped with Workhorse Custom Chassis, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result in the underhood area which may result in a fire. Correction: Dealers will replace the engine fuel rail pulse damper retainer clip.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
Certain motorhomes fail to comply with the requirements of CMVSS 101 and 105. Incorrect software programmed into the instrument panel cluster may not allow activation of certain driver warning indicators. As a result, the instrument cluster may fail to illuminate the warning lamps indicating brake system failure. Correction: Dealers will reprogram the instrument panel cluster.
On certain motorhomes, the roof vent for the optional 4-door refrigerator was incorrectly located allowing excessive heat build-up which has the potential to ignite surrounding materials, resulting in personal injury and/or vehicle and property damage. Correction: Dealers will relocate the refrigerator roof vent.
Certain motorhomes may have insufficient clearance in the area where the fuel line and frame cross member intersect. The cross member may wear into the fuel line and cause a leak which has the potential to ignite, resulting in personal injury and/or vehicle and property damage. Correction: Dealers will inspect the fuel line for abrasion wear or damage, and pry the wiring support channel away from the line to provide additional clearance.
On certain vehicles, the seat belts do not meet the strength requirements of CMVSS 209. In the event of a crash, the seat belt buckle could release, leaving the occupant unrestrained, possibly resulting in serious injury or death. Correction: Dealers will replace the seat belt buckle assemblies.