Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2006 Thomas Built Buses SAF-T-Liner C2, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
CERTAIN MODEL YEAR 2000 THROUGH 2009 THOMAS BUILT SCHOOL BUSES MANUFACTURED FROM APRIL 17, 2000, THROUGH DECEMBER 21, 2009, WERE EQUIPPED WITH AN INCORRECT TIRE LOAD CERTIFICATION LABEL. THE CERTIFICATION LABELS LIST "D" LOAD RANGE TIRES WITH A RECOMMENDED COLD TIRE INFLATION PRESSURE GREATER THAN 65 PSI. THE BUSES ARE EQUIPPED WITH LOAD RANGE "E" TIRES THAT REQUIRE A HIGHER MINIMUM TIRE PRESSURE. ACCORDINGLY, THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." Remedy: DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE INCORRECT LABEL WITH A CORRECT LABEL FREE OF CHARGE OR, IF THE OWNER WISHES, THEY MAY REPLACE THE LABEL THEMSELVES. OWNERS SHOULD CONTACT DTNA AT 1-800-547-0712 OR THOMAS BUILT AT 1-336-889-4871 TO OBTAIN THE LABEL IF THEY WISH TO AFFIX IT THEMSELVES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 28, 2011.
DAIMLER TRUCKS IS RECALLING 22,206 THOMAS BUILT MY 2005 THROUGH 2010 SCHOOL BUSES MANUFACTURED FROM OCTOBER 2004 THROUGH NOVEMBER 24, 2008. THE LOWER END OF THE FRONT ENTRANCE DOOR AFT ASSIST HANDRAIL MAY BE LOCATED TOO CLOSE TO THE STEP. Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS AND DIRECT WARRANTY CUSTOMER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 6, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 SAF-T-LINER C2, SAF-T-LINER HDX, MVP-EF, FS-65, AND MINOTOR SCHOOL BUSES MANUFACTURED FROM JANUARY 2, 2006, THROUGH JANUARY 31, 2011, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING. Remedy: DTNA WILL NOTIFY OWNERS AND PROVIDE INFORMATION ON HOW TO OBTAIN THE RETROFIT KIT FROM CARRIER ALONG WITH REPAIR INSTRUCTIONS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 20, 2011. (SEE CARRIER'S RECALL CAMPAIGN 11E-003.) OWNERS MAY CONTACT CARRIER AT 1-800-793-4741 OR DTNA AT 1-800-547-0712.
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM APRIL 5, 2004 THROUGH DECEMBER 26, 2005. THE PASS-THROUGH POWER CABLE CONNECTIONS LOCATED BEHIND THE DRIVER'S SIDE KICK PANEL MAY CORRODE POTENTIALLY RESULTING IN AN ELECTRIC FAULT OR SHORT CIRCUIT. Remedy: THE FINAL REMEDY IS BEING DEVELOPED. DTNA WILL SEND OWNERS AN INTERIM NOTICE ADVISING THEM TO INSPECT THEIR BUSES FOR CORROSION IN THE AREA OF THE POWER TERMINALS, AND IF EXCESSIVE CORROSION IS FOUND, TO TAKE THEIR VEHICLE TO AN AUTHORIZED SERVICE FACILITY. REPAIRS WILL BE MADE BY DTNA FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM MARCH 9, 2004, THROUGH JANUARY 2, 2008, EQUIPPED WITH CATERPILLAR C7 ENGINES, HYDRAULIC BRAKES, AND A FUEL WATER SEPARATOR. THE FUEL LINE GOING FROM THE FUEL WATER SEPARATOR TO THE ENGINE MAY RUB ON THE HYDRAULIC BRAKE LINES POTENTIALLY RESULTING IN BRAKE FLUID LEAK. Remedy: DTNA WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE VEHICLES TO ENSURE THAT THERE IS THE CORRECT CLEARANCE BETWEEN THE FUEL AND BRAKE LINES. DAMAGED LINES WILL BE REPLACED. REPAIRS WILL BE MADE BY DTNA AUTHORIZED SERVICE FACILITIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES BUILT ON FCCC B2 CHASSIS MANUFACTURED FROM OCTOBER 15, 2004 THROUGH NOVEMBER 25, 2009, EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION. Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712.
DAIMLER TRUCKS IS RECALLING 243,435 MY 1995-2008 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 1994, AND MARCH 10, 2008. (ADDITIONAL BUSES HAVE BEEN ADDED TO THIS RECALL CAMPAIGN. PLEASE SEE SUPPLEMENTAL REPORT NO. 4) THE EMERGENCY EXIT DOOR HANDLE BEGINS CORRODING AROUND THE SECURING ROLL PIN AND SQUARE DRIVE MECHANISM CAUSING THE PROTECTIVE FINISH TO CHIP AND FLAKE. CONTINUED CORROSION AND PITTING WEAKENS THE HANDLE. HANDLES WEAKENED BY CORROSION MAY BREAK WHILE TRYING TO OPEN THE DOOR FROM THE EXTERIOR. Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPLACE THE HANDLES WITH A MORE ROBUST HANDLE FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY THOMAS BUILT BUSES DEALERSHIPS. THE RECALL BEGAN ON AUGUST 18, 2008, AND NOTIFICATION FOR THE REVISED POPULATION IS EXPECTED TO BEGIN ON OR ABOUT APRIL 29, 2009. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
DAIMLER TRUCKS IS RECALLING 15,686 MY 2005 THROUGH 2009 FCCC AND THOMAS BUILT SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN MARCH 2005 AND MAY 2008 EQUIPPED WITH A CERTAIN BRAKE LAMP AIR PRESSURE SWITCH. THE CONTACTS IN THE PRESSURE SWITCH FOR THE LOW CURRENT BRAKE LAMP SIGNAL TO THE CHASSIS ECU MAY HAVE BECOME CONTAMINATED BY SILICONE DURING ASSEMBLY CAUSING INSULATING DEPOSITS TO BUILD UP OVER TIME PREVENTING THE BRAKE LAMPS FROM OPERATING. Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE PRESSURE SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 18, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR THOMAS BUILT BUSES AT 1-336-889-4871.
DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS. Remedy: DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.
DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 24,650 SCHOOL AND NON-SCHOOL BUSES, MOTOR HOME CHASSIS, AND TRUCKS MANUFACTURED FROM MARCH 9, 2004 THROUGH AUGUST 18, 2006, EQUIPPED WITH EPA04 CERTIFIED MBE900 ENGINES, MANUFACTURED BY DETROIT DIESEL BETWEEN MARCH 1, 2004, AND JULY 31, 2006. THE HIGH PRESSURE FUEL LINES AND TRANSFER TUBES MAY FATIGUE AND FRACTURE. Remedy: DETROIT DIESEL WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED WITH MORE ROBUST LINES AND VIBRATION DAMPERS FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY AUTHORIZED DETROIT DIESEL DISTRIBUTORSHIPS. THE RECALL BEGAN ON MARCH 9, 2009. OWNERS MAY CONTACT DETROIT DIESEL 1-313-592-3708 OR DTNA TOLL-FREE AT 1-800-547-0712 FOR MORE INFORMATION.
CERTAIN MY 2005-2007 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED BETWEEN DECEMBER 1, 2003, AND OCTOBER 10, 2006. FASTENERS USED TO SECURE THE FUEL TUBE MOUNTING BRACKET TO THE BUS FLOOR MAY BE MISSING OR IMPROPERLY INSTALLED. VEHICLES WITH MISSING OR IMPROPERLY INSTALLED FUEL FILL TUBE MOUNTING BRACKET FASTENERS DO NOT COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 10, 2007. OWNERS CAN CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
CERTAIN 2005 THROUGH 2008 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM DECEMBER 1, 2003 TO MAY 18, 2007. THE EXTERNAL WARNING LIGHTS MAY STOP FUNCTIONING UNEXPECTEDLY IF THE FRONT ENTRANCE DOOR CLOSES WITHOUT THE DRIVER'S INPUT. Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
DAIMLER TRUCKS IS RECALLING 760 MY 2003-2007 THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 6, 2005 AND JULY 19, 2006, EQUIPPED WITH BRAUN WHEELCHAIR LIFTS, MODELS NL, NCL, OR NVL. THE THRESHOLD WARNING SYSTEMS OF THE SUBJECT MODEL WHEELCHAIR LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES. Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY WHICH WILL BE PERFORMED BY THOMAS BUILT DEALERSHIPS. THE RECALL BEGAN ON AUGUST 8, 2008. OWNERS MAY CONTACT THOMAS BUILT AT 336-889-4871.
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY. Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
CERTAIN THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN MARCH 8, 2006, AND AUGUST 10, 2007, EQUIPPED WITH ONE OR MORE "PRO LO ROOF HATCH" OPTION NUMBERS D107307001, D107307002, OR D107307003. RETROREFLECTIVE TAPE WAS NOT INSTALLED AROUND THE PERIMETER OF THE ROOF MOUNTED EMERGENCY EXIT HATCH. THESE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE. Remedy: THOMAS BUILT WILL NOTIFY OWNERS AND REPAIR THE BUSES BY INSTALLING RETROREFLECTIVE TAPE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 4, 2007. OWNERS MAY CALL THOMAS BUILT AT 336-889-4871 OR CONTACT FREIGHTLINER AT 800-547-0712.
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2004 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 non-school buses. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode. Remedy: DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. An interim notice was mailed to owners on August 28, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.
Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 transit buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair. Remedy: DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim letter was mailed on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.
Daimler Trucks North America LLC (DTNA) is recalling certain 2005-2018 Thomas Built Buses Saf-T-Liner C2 school buses. In the event of a crash, the wheelchair pocket track anchorage may not adequately secure a the wheelchair. Remedy: DTNA will notify owners, and dealers will add additional fasteners to the wheelchair pocket track to reinforce the anchorage, free of charge. An interim notice was sent to owners on September 13, 2017. The recall began on December 20, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-743.
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Thomas Built Buses Saf-T-Liner C2, Saf-T-Liner HDX, FS65, and Minotour school buses, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf Remedy: DTNA will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin March 30, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Kidde customer service at 1-855-262-3540 or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2002-2013 Thomas Built Buses Saf-T-Liner ER, 2001-2005 Saf-T-Liner Conventional, 2002-2013 Saf-T-Liner MVP-EF, 2013 Saf-T-Liner EFX, 2001-2008 Saf-T-Liner FS65, 2005-2013 Saf-T-Liner C2, 2003-2013 Saf-T-Liner HDX, 2002-2003 Saf-T-Liner MVP-ER, 2002 Vista, and 2002-2003 TL-960 school buses manufactured from February 5, 2001, through May 29, 2012. In the affected vehicles, the stem that connects the outside emergency door handle to the emergency door opening mechanism may corrode. Remedy: DTNA will notify owners, and dealers will either replace the stems or protect them against corrosion, free of charge. Daimler issued an interim notification to owners on August 25, 2015. The recall began on December 24, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-685.
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2006-2015 Thomas Built Buses FS-65, Saf-T-Liner C2, Saf-T-Liner EF, Saf-T-Liner EFX, Saf-T-Liner HDX, and Minotour DRW school buses manufactured January 3, 2006, to August 1, 2014, and equipped with certain Ricon model S2005, S2010, S5005, S5010, S5505, S5510 wheelchair lifts. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position. Remedy: DTNA will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began onNovember 2, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-686.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain