Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2009 Volkswagen Routan, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles manufactured June 25, 2008, to July 8, 2009, and 2010 Routan vehicles manufactured October 1, 2009, to August 11, 2010. This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. Remedy: Volkswagen will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on June 23, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 28H1. Note: This recall supersedes recalls 11V151 and 14V396. Vehicles that previously received an ignition switch trim ring as a recall remedy must have their vehicles remedied again under this campaign. Vehicles that have already received a new ignition switch are not covered by this campaign.
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure. Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Volkswagen Group of America, Inc. (VW) is recalling certain model year 2009 Volkswagen Routan vehicles manufactured February 7, 2008, to August 28, 2008. In the affected vehicles, the air bag control units may corrode and fail. Remedy: VW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began April 2016. Owners may contact Volkswagen customer service at 1-800-893-5298.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009 Routan vehicles. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. Remedy: Volkswagen will notify owners, and dealers will modify the ignition switch, free of charge. Owners may contact Volkswagen customer service at 1- 800-822-8987. An interim notice was mailed to owners on August 29, 2014. Volkswagen's number for this recall is 28G1/U8. Note: This campaign is an expansion of NHTSA Recall No. 11V-151.
VOLKSWAGEN IS RECALLING 18,500 MY 2009 ROUTAN VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE OWNER'S MANUAL WAS PRINTED WITHOUT THE FMVSS NO. 208 REQUIRED INFORMATION EXPLAINING THAT NO OBJECTS SHOULD BE PLACED OVER THE OR NEAR THE AIR BAG ON THE INSTRUMENT PANEL. Remedy: DEALERS WILL SEND AN OWNER'S MANUAL INSERT CONTAINING THE REQUIRED AIR BAG INFORMATION FOR OWNER INSTALLATION OR DEALERS WILL INSTALL IN THE EVENT THE OWNER PREFERS ASSISTANCE FROM THE DEALER. THE RECALL BEGAN ON JULY 31, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR. Remedy: VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
On certain vehicles, a defect in the Occupant Restraint Control (ORC) system could result in inadvertent airbag / seatbelt pretensioner deployment, or prevent airbags / seatbelt pretensioners from deploying when warranted. Unintended airbag / seatbelt pretensioner deployment, in a non-warranted (non-impact) situation, could startle the driver, and could result in a vehicle crash causing injury and/or property damage. Furthermore, failure of the airbags / seatbelt pretensioners to deploy in a crash when warranted could increase the risk of injury to vehicle occupants. Correction: Dealers will replace the Occupant Restraint Control (ORC) module.
On certain vehicles, the Wireless Ignition Node (a.k.a ignition switch) may allow the ignition key to inadvertently move from the ON position to the accessory (ACC) position while driving, causing the engine to shut off. This would result in a loss of motive power, power steering and power brakes, and would disable the airbags as well as other supplemental restraint systems (SRS). Increased steering and braking effort and a loss of motive power could increase the risk of a crash causing injury and/or damage to property. Loss of airbag / SRS function in a crash that warrants airbag deployment and/or other supplemental restraint system function could increase the risk of injury to vehicle occupants. Correction: Dealers will inspect the WIN module and install a secondary detent system if required. Note: This recall is an expansion of recall 2011095.
On certain vehicles modified for wheelchair accessibility by the Liberty Motor Company Inc., the rear axle may fracture due to a combination of corrosion damage and operation on rough roads. If the rear axle fractures, vehicle handling may be adversely affected, creating the risk of a crash and increasing the risk of injury and/or property damage. Correction: Freedom Motors assigned service shops will inspect axles and reinforce or replace as necessary.
Problems owners of this model reported to NHTSA, grouped by component.
Source: NHTSA (US Department of Transportation) · US public domain
Crash-test ratings from NHTSA's New Car Assessment Program.
Source: NHTSA (US Department of Transportation) · US public domain
On certain vehicles equipped with power sliding doors, the sliding door wiring harness may have been routed improperly and chafe on the lower sliding door hinge bracket. This could result in a fire within the sliding door assembly, which could lead to property damage or personal injury. Correction: Dealers will inspect the sliding door wire track harness and power drive unit wiring harness assemblies for damage. The harnesses will be repaired or replaced as necessary, and rerouted under the sliding door weatherstrip.
The owner's manual for certain vehicles was printed without the CMVSS 208 required information explaining that no objects should be placed over or near the airbag on the instrument panel, because any such objects could cause harm if the vehicle is involved in a crash severe enough to cause the airbag to inflate. Correction: Owners will be provided with an owner's manual insert containing the required airbag information.