Loading NHTSA data…
Loading NHTSA data…
Recalls, inspection results and owner complaints for the 2020 Volvo XC60, from official sources in the US, Canada and Europe. To check one specific car, enter its VIN or plate.
We checked recall campaigns for this vehicle, or for its model where the register works by model.
Source: NHTSA (US Department of Transportation) · US public domain
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended. Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system. Remedy: Dealers will replace the hydraulic unit, free of charge. Owner notification letters were mailed October 22, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10120.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail. Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Volvo Car of N.A., LLC (Volvo Cars) is recalling certain 2018-2020 XC60 vehicles. The nuts that secure the front wipers may not have been sufficiently tightened, possibly causing the wipers to not function properly. Remedy: Volvo Car will notify owners, and dealers will tighten the nuts holding the front windshield wiper arms in position, free of charge. The recall began September 29, 2020. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10044.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing. Remedy: Dealers will replace the steering gear, free of charge. Owner notification letters are expected to be mailed March 1, 2023. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10213.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked. Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
We checked Transport Canada's recall database for this make, model and year.
Source: Transport Canada Vehicle Recalls Database · Open Government Licence – Canada
Issue: On certain vehicles, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit. Note: This recall only affects certain plug-in hybrid (PHEV) models. Safety Risk: A short circuit in the high-voltage battery can create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: To reduce the safety risk, Volvo advises not to charge your vehicle until the recall repairs have been completed. Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the high-voltage battery module(s). The dealer will also install an advanced diagnostic software that will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the affected high-voltage battery module(s).
Issue: On certain vehicles, the rods connecting the brake pedal to the hydraulic brake unit may not have been assembled properly. As a result, the rods could loosen, and you may experience a change in brake pedal feel. This can cause reduced braking. Safety Risk: Reduced braking can cause extended stopping distances and increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, tighten the brake pedal pushrod screw.
Issue: On certain vehicles, a software problem could cause the top-view camera to display instead of the rearview camera image when you are reversing. Canadian regulations require the rearview image to display when reversing. Note: This recall only affects vehicles equipped with a 360-degree park assist camera. Safety Risk: A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners in writing and send a wireless over-the-air update to each vehicle. If the update cannot be completed successfully, or for vehicles without over-the-air (OTA) update capability, Volvo will instruct you to schedule an appointment to have the update performed by a dealer.
How cars of this model and year did at Norway's periodic inspection, across a full year of tests.
Source: Statens vegvesen, periodic inspections (EU-kontroll) · CC BY 4.0
Issue: On certain vehicles, the fuse for the low-pressure fuel pump may be too small. As a result, the fuse could blow and the engine could stall while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Action: Volvo will contact owners by mail and instruct you to take your vehicle to a dealer to replace the 15 A fuse for the low-pressure fuel pump with a 20 A fuse.
Issue: On certain vehicles, the nuts that attach the windshield wiper arms may not have been tightened properly. This could cause the wipers to slip and not clear the windshield properly. Safety Risk: Windshield wipers that do not work properly could affect a driver's visibility. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to tighten the nuts on the windshield wiper arms.
Issue: On certain vehicles, the automatic emergency braking system (AEB) may not apply the brakes automatically when it detects a possible collision. In addition, the system may not warn of a potential crash with a non-moving vehicle or object. Note: The regular brake system and all other functions in the vehicle are not affected by this problem. Safety Risk: The AEB system may not provide driver warnings and apply the brakes automatically to help avoid a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to update the vehicle software.